Know Your Mini Moto

The Mini Moto is a small scale replica of the World Super Bikes used by the likes of Valentino Rossi and ex champion Carl Fogarty. The Mini Moto comes equipped with either a two stroke air or water cooled engine which are, depending on the model, capable of speeds of up to 60Mph.

In this article I will underline the finer points of the components that make these speeds possible.

The two Stroke Engine

The two stroke engine produces more hp per pound than the four stroke engine. The two stroke engine consists of three moving parts, the piston, the rod and the crank. The piston acts as valve that opens and closes the intake and exhaust ports that are located on the walls of the cylinder. Unlike the four stroke engine that fires only every other time of the pistons movement, the two stoke engine fires every time the piston reaches the top of its travel. This means that the time spent generating power is doubled in the two stroke engine than that of the four stroke engine, as there is no engine coasting during passive cycles. This is the main reason that the two stroke engine can rev more highly and produce more power (for its size) that the four stroke.

Fuel

The two stroke engine needs to be run on a mixture of petrol and two stroke oil. This is so that the engine is kept lubricated whilst in use.

99% of all starting problems are caused by fuel problems. These can stem from bad or old fuel and improperly mixed fuel (please see mixing chart). Do not use fuels that contain alcohol, as the can cause you bike to run 'lean'. Be advised some racing fuels contain alcohol and are best avoided.. We recommend that you use normal petrol for a garage and a quality two stroke oil.

A mixture that is too lean I.e not enough two stroke oil can damage your mini moto's engine as the moving parts are not properly lubricated. This can cause the engine to seize. However a mixture that is too rich can choke the engine and effect the performance and cause starting problems. You can tell if your mini moto is running too richly by the plumes of white smoke coming out of the exhaust and the lack of performance. A rich mixture (25:1) is needed to lubricate the engine during the 'run in' period, you may experience a lack of performance during this period. The pocket bike may run more slowly and acceleration can be sluggish, however when you change to a mixture of 50:1 you will really notice a difference. The leaner mix ignites in the combustion chamber faster and with a more explosive force than the richer mix. This means higher revs which means more power and acceleration.

We recommend that a fuel mixture of 25:1 is used to 'run in' you mini moto, and a mixture of 50:1 is used thereafter.

'Running in'

Your mini moto should be 'run in' for the first 3-4 tanks of fuel. During this period we recommend that you use a fuel mixture of 25:1. This means a mixture that is made up of 25 parts petrol to 1 part of two stroke oil. During the 'running in' period be careful to not rev the engine to its maximum as this can damage the engine. The 'running in' period will allow the moving parts to become well oiled and the clutch and brakes to 'bed' themselves in. After you have run the minimoto on this fuel mixture for 3-4 tanks, check the chain and tighten accordingly, check the tyre pressure, tighten the bolts on the brakes, forks and wheels. You may also need to readjust the throttle settings to allow for the higher revs that changing to a leaner fuel mix produces. The bike should now be ready for a fuel mixture of 50:1.

Clutch

The mini moto uses a centrifugal clutch to power the drive the sprocket, which in turn drives the back wheel of your mini moto.

When you start your mini moto the clutch spins as the engine ticks over . The clutch is engaged when you pull back on the throttle. The increase in speed of revolution of the clutch makes the clutch expand and grip the inside of the clutch bell which turns the sprocket that drives the back wheel of your pocket bike.

The clutch can be set up in different ways depending on the type of performance that you want from your minimoto. Adjustable clutches are not standard on mini moto's but an after market Polani or Blata style adjustable clutch can be used in your new mini moto. These allow the rider to adjust the mini moto's set up in according to their preference. Setting the clutch to engage too late when the engine has built up too much power may cause the clutch to slip and never fully engage. This can result in excessive wearing. However setting the clutch to engage too early, before the power has built up in the engine can cause your pocket bike to 'bog down', resulting in slow acceleration. The perfect set up is to get the clutch to engage just as the engine has built enough power to rocket the mini moto away, but without making the clutch slip, this is achievable through trial and error.

Spark Plug

Making sure that your spark plug is fresh is important in a two stroke mini moto engine. You can tell a lot from the colour of the spark plug. The top part of your spark plug is covered in ceramic insulator which, when brand new is white. This part of the spark plug can change colour according to how your engine is running. The plug should appear as a nice tan colour when the engine is running perfectly, this indicates complete combustion. A greyish or white colour indicates that the engine is running too lean which can result in engine damage. In this case you should clean and check your fuel system for any obstruction, check your fuel mixture, check for loose intake manifold bolts and carburettor mounting leeks, faulty gaskets and leaking crank seals. Anywhere that your engine could potentially leek and suck in fresh air can be the source of a lean condition.

A blackened or oily spark plug indicates improper combustion and is the result of running too rich. This can be caused by too much oil in the mixture or the spark plug could be faulty and misfiring. Check the fuel mixture and replace the spark plug.

Air Filter

Your new mini moto is equipped with an air filter. Some bikes such as the B1 Origami rep liquid cooled and the Mini Dirt bike have a 'cone' style K and N style air filter. The 2005 mk2 mini moto and the B1 Origami Replica air cooled bikes have a standard mini moto air filter. Both air filters purify the intake of air that is sucked into the carburettor. This means that the air filter should be cleaned regularly as the mini moto's performance can begin to suffer as the engine can become starved of air if the air filter is choked with debris. To reach the air filter, remove the bikes bottom fairing, remove the protective cover by unscrewing the holding screws. Clean the air filter in petrol but make sure that the filter is dry before reattaching to you mini moto.

Tyres

The tyres on your mini moto are filled with air (pneumatic). Please consult your mini moto handbook for the appropriate psi. It is important to check the tyre pressure regularly, an under inflated tyre will affect the performance of your mini moto, acceleration can become sluggish and cornering can become dangerous.

Chain

Before riding your mini moto you need to make sure that the front and back sprockets are aligned and that the chain is perfectly straight running between them. Once you have established this make sure that the chain is tensioned correctly (please see your mini moto handbook). To test the tension of the chain you can manually push the pocket bike, if you hear a 'pinging' or 'popping' sound the chain is too loose. If the chain is noisy and starts to bind the chain is too tight. Make sure that the chain is well oiled. The chain needs to be oiled before every ride.

Gearing

The gearing of you mini moto is dictated by the number of the teeth on the front sprocket and on the back sprocket. The sprockets can be changed as an easy way to manipulate top end speed and acceleration, quite like changing gear on a mountain bike. A front sprocket with more teeth will improve acceleration, however the top end speed will be reduced. A larger rear sprocket will produce a higher top speed but acceleration will suffer. The gearing on your bike can be adjusted in accordance for the track you are intending to ride I.e. a small track with a lot of bends will suit gearing for improved acceleration, however a track with long straights will require a mini moto that is geared for a higher top speed.

Throttle

The throttle on your new mini moto is a 'twist grip' style throttle. When you twist the throttle the throttle cable is pulled back revving the engine. It is important to keep this cable free from obstacles and clean. If the throttle begins to feel 'loose' of 'gives', the tension of the cable can be adjusted via the adjusting screw.

Brakes

The brake system comprises of brake levers, brake cables, brake callipers and brake discs.

The brakes on your mini moto are operated by levers found on the handle bars. The right hand brake controls the front brake, and the left controls the back brake. Pulling on the handle pulls the brake cable which in turn pulls the lever located on the bake calliper. This action pushes the brake discs towards each other. This creates friction on the brake disc which slows down or stops the bike.

The brakes can be adjusted in the following ways.

The brake cable can be tensioned using the adjustment screw found on the brake lever. Unscrew the locking nut, twist the screw to reach the desired tension. Re screw the locking nut.

This is a two person job. Adjust the screw on the hand brake so that is at the end of its travel. Undo the clamp that holds the brake cable on the lever located on the brake calliper. One person needs to push the lever forward as far as it will, the second person needs to pull back on the brake cable and re fasten the clamp. The crake cable will now be highly tensioned.

Pull Start

To start the mini moto pull slowly to turn the fly wheel. This pumps some fuel around the engine, which lubricates the moving parts. Pull the pull start firmly in order to start the engine. Important, do not pull the cord to the end of its run as it can break. If the mini moto does not start check the choke and the throttle cable.

Choke

The choke controls the amount of air that is allowed into the air/fuel mix. The choke is adjusted via a lever located on the side and back of the engine. The choke is off when the lever is down, and on when the lever is up. When you start the mini moto the choke should be on, when the mini moto is warm and ready to ride the choke needs to be off.

Carburettor

It is recommend that any adjustments to the carburettor are made by a professional. The carburettor pumps and mixes the fuel and air. The small diaphragms, orifices and ports mix the air and fuel very precisely, this process demands clean fresh fuel.

Jet

The jet can be adjusted by the screw located in the access hole to the right of the choke lever. The jet is adjusted by the manufacture however the conditions of where you wish to ride may be different, which means that you will need to make adjustments. Turning the screw clockwise will make the bike run with a leaner mixture, and counter clockwise will richen the mixture. Only adjust the screw 1 tern a at time and then test the mini moto, this is trail and error. Please note that it is best to find the optimum setting for performance and then run a slightly richer mixture as a mix that is too lean can seize the engine.

Matt Tong has been importing and riding Mini Motos for over two years. For more information please visit http://www.minimotosandmore.com

---

Google News Updated : Tue, 07 Oct 2008 20:50:00 GMT Get moving: Guidelines set healthy activity levels - The Associated Press ABC News Get moving: Guidelines set healthy activity levels The Associated Press - 38 minutes ago WASHINGTON (AP) - Get moving: New exercise guidelines released Tuesday set a minimum sweat allotment for good health. For most adults, that's 2 1/2 hours a week. Government tells Americans to take stairs, go out and play Bizjournals.com Get 2 1/2 hours of exercise per week, US says Reuters USA Today - Food Consumer - MarketWatch - MyFox Dallas all 183 news articles Publ.Date : Tue, 07 Oct 2008 20:11:51 GMT Union-Backed Party Opposes Term Limits Plan - New York Times New York Daily News Union-Backed Party Opposes Term Limits Plan New York Times - 1 hour ago By Fernanda Santos The Working Families Party began on Tuesday the labor community’s first major offensive against Mayor Michael R. Bloomberg’s plan to change term limit laws through legislation that would extend to three, from two, the number of terms ... UPDATE 1-NYC lawmakers to weigh bill raising term limits Reuters Bill to end term limits introduced in City Council New York Daily News New York Times Blogs - WNYC - Campaigns & Elections - Crain's New York Business all 331 news articles Publ.Date : Tue, 07 Oct 2008 19:15:23 GMT Fed Announces Plan to Buy Short-Term Debt - New York Times Telegraph.co.uk Fed Announces Plan to Buy Short-Term Debt New York Times - 58 minutes ago By EDMUND L. ANDREWS and MICHAEL M. GRYNBAUM WASHINGTON - The Federal Reserve announced a radical new plan on Tuesday to jump-start the engine of the financial system. Fed makes boldest move yet Christian Science Monitor Federal Reserve to buy up short-term commercial debt Los Angeles Times Bloomberg - NECN - The Associated Press - Wall Street Journal all 1,716 news articles Publ.Date : Tue, 07 Oct 2008 19:51:44 GMT Axelrod Says Obama Will Counterpunch if McCain Raises Ayres - New York Times Axelrod Says Obama Will Counterpunch if McCain Raises Ayres New York Times - 2 hours ago By Patrick Healy NASHVILLE - Senator Barack Obama is prepared to hit back, including with Keating Five scandal if necessary, if Senator John McCain uses tonight’s presidential debate to attack him over his associations with controversial figures like ... Video: AP Campaign Minute AssociatedPress Palin Adds Fannie Mae Execs to List of Objectionable Obama Associates Washington Post The Associated Press - U.S. News & World Report - FOXNews - Christian Science Monitor all 4,761 news articles Publ.Date : Tue, 07 Oct 2008 18:32:14 GMT Kenya deports anti-Obama author - Christian Science Monitor BBC News Kenya deports anti-Obama author Christian Science Monitor - 4 hours ago Jerome Corsi, author of "Obama Nation: Leftist Politics and the Cult of Personality," tried to launch his new book, but violated immigration rules, Kenyan officials say. Barack Obama's African grandmother Sarah Onyango Obama roots for him Times Online Anti-Barack Obama author detained while promoting his book in Kenya Los Angeles Times AFP - The Associated Press - New York Times - BBC News all 507 news articles Publ.Date : Tue, 07 Oct 2008 16:09:55 GMT Study: Using fan on sleeping baby reduces risk of SIDS - San Jose Mercury News dBTechno Study: Using fan on sleeping baby reduces risk of SIDS San Jose Mercury News - 8 hours ago By Linda Goldston Ayde Gonzales's mother was surprised when she insisted that her newborn son must sleep on his back, not on his side. Fan Use May Save Your Baby’s Life, Reduces SIDS Risk eFluxMedia Fan in Room Seems to Cut Infants’ Risk of Crib Death New York Times Bloomberg - Wall Street Journal - U.S. News & World Report - WebMD all 612 news articles Publ.Date : Tue, 07 Oct 2008 12:46:19 GMT Fitch says AMD factory move has no ratings impact - Forbes Canada.com Fitch says AMD factory move has no ratings impact Forbes - 51 minutes ago AP 10.07.08, 3:48 PM ET Fitch Ratings said Tuesday Advanced Micro Devices Inc.'s ratings are not affected by the chip maker's plans to spin off factories into a new joint venture with investors in the Persian Gulf state of Abu Dhabi. What AMD's fab spinoff means for Intel, industry MarketWatch Who Benefits From AMD’s Financial Engineering? New York Times The Associated Press - BusinessWeek - Motley Fool - Bizjournals.com all 656 news articles Publ.Date : Tue, 07 Oct 2008 19:58:11 GMT RSS For Web Pages Web Site Traffic

PARLOT::Ebooks, Scripts, Websites, and more...

Adsense websites

Honda Super Cub and 50cc Honda Cub - The Volkswagen Beetle of Motorcycles!

A very clever design: the Honda Super Cub was the... Read More

The Motorcycle Helmet You Want May Not Be As Safe As You Think!

Choosing the right Motorcycle helmet can make a difference?.?.literally between... Read More

Motorcycle Radar Detectors

Standard radar detectors were not built for motorcycles and were... Read More

Motorcycle Protective Clothing That Works!

There is some great looking motorcycle clothing on the market... Read More

Yamaha Motorcycles - Creativity and Spirit of Challenge

"If you are going to do something, be the best"... Read More

Motorcycle Helmets - Mind Your Head!

To most riders, motorcycle helmets do not fit into their... Read More

People Are Crazy... and Everyone Is A Racer

?And everyone is a racer. If you doubt that, you've... Read More

Ride Hard - Hydrate Harder

This summer is showing all of the signs of being... Read More

Suzuki Motorcycles - From Fine Loom Manufacturers to Major Motorcycle Company

Started in a small warehouse by Michio Suzuki back in... Read More

Trackdays - Get the Maximum Enjoyment from Your Time on the Track

Many motorcyclists want to take their bikes onto the track... Read More

Women and Motorcycles? You Bet!

To really understand the women and her ride, one needs... Read More

It?s One Thing for People to Buy Your Product or Service, but It?s Another for Them to Tattoo Your

William Harley and Arthur Davidson, both in their early twenties,... Read More

Auctions and Car Transport: Everything You Need To Know

Everyone has wanted to sell a car at some point... Read More

Motorcycle Suspension: - A Troubleshooting Guide

Trouble Shooting Suspension Problems.Adjustment locations: ForksRebound adjustment (if applicable) is... Read More

Personal Scooters are Not Just for Fun

Personal scooters are a highly valuable mobility tool for those... Read More

How To Make Your Own Vintage Motor Cycle & Automotive Spare Parts

Vintage Car & Motorcycle restoration enthusiasts all share one thing... Read More

Workings of a Motorcycle Muffler Suspension

Motorcycles are becoming more popular because of its convenience and... Read More

Save Money on Used Motorcycle Parts

For every motorcycle enthusiast, it is indeed very taxing to... Read More

Mini Moto Tips

These are some quick adjustments and tips for the B1... Read More

Motorcycle Accidents: Preparing Your Case

Motorcycle accident is an unexpected occurrence that results to shock... Read More

Kids Like to Ride Motorcycles Too

Roaring up on a motorcycle has a strong draw for... Read More

A Great Motorcycle Ride in Mexico: Queretaro

A beautiful ride across cities and places named World Heritage... Read More

Ghost Minimoto Moto GP Reps ? What Are They?

What are Mini moto's? A Minimoto is a miniature version... Read More

Necessity of Motorcycle Parts

If you are one of the many people who consider... Read More

Frame Slider Design and Selection

Call them crash protectors, crash bobbins, fairing protectors or frame... Read More